How To Fix Garage Door Wheel Off Track
Its happened to most of us. You go to pull the garage door open, and only one side budges. So you investigate and discover that one of the wheels has come off the track. Garage door wheel off track can be a real annoyance, but its a problem that can easily be fixed. In this article, we will give you a few tips on how to fix garage door wheel off track yourself. So read on and get your garage functioning like new again!
The garage door is one of the essential parts of our house. It helps to keep our car safe from bad weather and thieves. However, it can be a real pain when the garage door wheels off the track. Not only that, but it can also be dangerous if not fixed properly. Many people have been injured by a garage door that has come off its tracks.
Track Is Out Of Alignment
Make sure that the tracks for your garage door rollers are in their proper alignment by using a level. If you have a horizontal track, they should have a slight angle towards the back of your garage. If you are using a roll-up door, the track section should be precisely leveled. If they are not sitting correctly, loosen the brackets that hold them in place. Then, tap on them carefully until they have a perfect alignment. Tracks should also be of the same height on either wall.
What The Rollers Do
The rollers in your garage door allow the door to open and close smoothly. All the moving parts of a garage door need to be aligned for it to work properly. If you notice that the rollers have jumped the track, immediately stop using the door until it can be repaired. Continuing to use the door when the rollers are off track can cause serious damage to the tracks or even the door itself. If this happens, you will need to bring in a professional to realign the whole structure or replace bent door panels.
Don’t Miss: Average Cost To Replace Garage Door
Checking For Loose Rollers
Taking a look at the tracks of your garage door is one of the first steps to solve this problem. If there are any dent or bent areas, you can use a wooden block to secure the track.
If the rollers are not sliding back into the track, you can use a rubber mallet to knock it back into place. If it doesnt work with a rubber mallet, you can remove it with a set of vise-grips. You can now test the track and see if the door moves correctly.
If the tracks have come off the wall, the rollers can come off the track. To prevent this problem, you can tighten the brackets that hold the rollers.
A ratchet handle or a wrench can be used to tighten the brackets. If the rollers are loose, you can clean them using a cleaning solution. The rollers may be off track due to a lack of lubrication.
Keeping the track clean is essential to avoid damage to the tracks. If the rollers are worn, they can be dangerous, and if the door is off track, you need to have it repaired.
You should also test the opener motor manually before hooking it up to ensure it is functioning properly. This preventative maintenance will ensure that your garage door is safe to use. You can also replace damaged rollers if you feel uncomfortable attempting to do it yourself.
Another common cause of garage door wheel off track is impact. The impact usually results from an accident. The opener should be opened slowly and carefully, as a slight impact can seriously damage the door and track.
What Are The Steps On How To Fix Garage Door Roller Off Track
Regardless of whether you hire professionals to take care of your home, these are the steps you need to take to fix off-track rollers
Step 1 Disconnect the main power to your garage door this forces the system into manual operation mode and gives you the freedom to move the door according to your repair needs.
Step 2 Identify a part of the track you need to guide a roller and hold it open using vice grips. Once you have the rollers ready, remove the vice grip.
Step 3 Next, youll have to close the track. Here, grab a small mallet and hammer the track to revert it to its original position.
Step 4 Clean the track and remove all dirt and grime this is essential, as you wouldnt want to end up with off-track rollers again right after you go through setting them in place.
Step 5 Apply plenty of lubrication so your rollers dont fall out of place again.
Step 6 Check the door to ensure its working correctly and all rollers are in place.
Step 7 Reattach power and ensure automatic mode is working.
Don’t Miss: Garage Door Won’t Open Liftmaster
How Do I Keep My Garage Door Rollers On The Track
Garage door rollers can come off the track for a variety of reasons. If your garage door rollers are regularly coming off the track, you might need to adjust. Here are a few tips on how to keep your garage door rollers on track:
- Make sure that the tracks are correctly aligned and parallel to each other.
- Check for any obstructions in the tracks that might be causing the rollers to come off. Remove any obstructions if possible.
- Lubricate the tracks and rollers with a silicone spray lubricant. This will help them to move more smoothly.
- If all else fails, you might need to replace the rollers or tracks. Talk to a professional about getting new parts for your garage door.
Following these tips should help to keep your garage door rollers on track.
Garage Door Wheels Off Track Why It Happened And How To Fix It
The majority of homes in America have garages over 63% in 2017. Garages are vital for storing vehicles, outdoor tools, and equipment. So when one isnt working, that disrupts how a home operates.
If you go to investigate and find that your garage door wheels have come off the track, theres more youll need to do than just reset and align them. Heres what likely happened, and some tips for how you can prevent it from happening again.
Recommended Reading: Genie 3-button Garage Door Opener Remote
The Track Is Loose Or Anchors Are Bad
There are a few reasons your garage door track might be loose, or the anchors might be bad. If your garage door is old, it might be wearing down, and the anchors arent holding the track in place as well as they used to. Alternatively, if there was a recent storm or something else that caused damage to your garage door, it could be that the track has become loose or one of the anchors has come loose.
Fortunately, this is a pretty easy fix. First, tighten the screws or bolts holding the track in place. If one of the anchors has come loose, you can reattach it with some screws or nails. Ensure that the track is nice and tight before you close the garage door again.
If your garage door is old and the anchors arent holding the track in place as well as they used to, you might want to consider replacing them altogether. This is a pretty straightforward process, and it can be done with just a few simple tools.
How To Fix A Garage Door Off Track
Garage doors are made functional by a system of rollers, tracks, and switches. It takes quite a bit of force to raise and lower such a heavy door so frequently. Garage doors also receive quite a bit of use, day in and day out. So its understandable when things go wrong, like when the door itself comes off the tracks.
The best way to address any problems with your garage door is to consult a garage door professional for their assistance. They can assess the problem and either make suggestions or repairs to help the door run more smoothly. They can also advise you as to whether you should replace your garage door entirely.
However, a garage door coming off the tracks is a common problem that the homeowner can fix his or herself with a bit of instruction. Further, understanding why rollers derail can help you prevent this problem from occurring in the first place. If youre facing a garage door dilemma, consider the following steps to solving that problem.
Heres how to fix garage door off track.
Contents
Don’t Miss: Parts For Craftsman Garage Door Opener
Panel Replacement In Austin Tx Is Important And Heres Why
by edih99 | Aug 11, 2016
Why Is Your Garage Door Wheel Popping Off the Track and What to Do About It
If you own a garage, you know the kind of work and maintenance that goes into making sure it always performs the way it should. Sometimes, however, things go wrong despite the high level of care you may be giving your garage door. One major problem people often have to deal with is the wheel / roller popping off track when the garage door is opening or closing. Many people experience this problem, but they often dont quite know what is causing it or what to do about it. Below is a glance at the different kinds of issues that may be causing your wheel to come off the track, as well as some easy and inexpensive solutions to how to solve it.
The first thing you should do when youve noticed that your wheel or your roller is coming off the track is to inspect the situation. Check to see if its the wheel that is coming off the track, or if its the door itself causing the wheel to come off the track. There are times that the garage door or a part of the door may become bent or damaged, and this is the reason your wheel is coming off your track. If this is the case, you may need to have a garage door repair expert come in to look at your door for solutions to the problem.
How May We Help You?
The Rollers Are Damaged
First and foremost, check garage door rollers. They should look round, have smooth-edged, and have no major damage or wear on them. If they wobble significantly or get stuck while rolling theyll likely need to be replaced.
Just because youve found one bad roller doesnt mean you shouldnt inspect the others. While one bad roller can cause everything to stop, multiple bad rollers can cause serious damage to your entire garage door setup.
New rollers are inexpensive and rather easy to install yourself.
Read Also: 2 Post Car Lifts For Home Garage
Fixing A Garage Door Wheel Off Track
The first step in fixing a garage door with a wheel off track is to locate the door itself. If the wheel is loose, lift the door until it is aligned with the track.
You can use locking pliers or vice grips to hold the door in place while you pull it off the track. If you dont have any experience with garage doors, call a technician to come and assist you.
When working on a garage door, always use caution when trying to fix a jammed wheel. It can be very heavy and could potentially slam on your body when you open it.
You may need to hire someone else to open it for you. This repair can be complicated, so its best to have the assistance of a technician. If youre a novice, it can be difficult to determine which wheels are jammed.
First, check the track for loose nuts or bolts. If there is no movement, check for broken hardware that can cause the door to fall off the track. The garage doors track is a very important component and a jamming wheel could damage it.
When it comes to removing the jammed wheel, remember that its easy to damage other components of the door. Using pliers will stop the track, but it can be tricky to locate the broken wheel in the first place.
In some cases, the tracks may need to be replaced. If you dont know how to remove heavy dents and other damage from the track, you can try using a rubber mallet or hammer to strike the dent.
Quality Residential And Commercial Garage Door Installations And Products
Markham Garage Doors provides the largest selection of residential and commercial garage door products and accessories throughout the Markham area. Our team of friendly and experienced garage experts provides individualized attention to all of our local customers recommending the highest-quality products from leading manufacturers like Clopay® and LiftMaster and finding unique solutions that suit your specific needs, improve your daily conveniences and fit your budget.
You May Like: Types Of Garage Door Bottom Seal
The Best Markham Residential Garage Door Services
At Markham Garage Doors, our team is dedicated to always providing Markham homeowners with attractive and dependable garage door products. All of our Clopay garage doors are crafted from the finest quality steel, aluminum and wood available, and extensively tested against the harshest climates to ensure lasting durability and beautiful appearances. Our residential garage door products are safe, easily maintained and energy-efficient.
Along with quality construction, these doors are designed to feature todays latest visual aesthetics, including a variety of colour and stain options, hardware and window texture options.
For every new garage door installation, well also help maximize your doors performance and efficiency with a state-of-the-art LiftMaster garage door opener. We stock the latest opener models featuring the most advanced upgrades available today, including Wi-Fi connectivity and MyQ, Security+ 2.0 with rolling door codes, timer-to-close and battery backup.
Track Adjustment Services In Boston
Its necessary to get regular track adjustments for your doors.
First, you will have well-maintained doors that can guard your garage.
Second, fewer gaps will allow unwanted break-ins and pest infestations if you adjust the tracks properly towards the entrance.
Lastly, you get to check the individual rollers inside the tracks.
A simple track adjustment can go a long way in ensuring that your garage is safe.
It also costs less to adjust a track than to deal with the damages from a falling or hanging garage door.
Recommended Reading: Garage Door Extension Springs Color Code
More About Dodds Garage Door Systems Inc
Dodds Garage Door Systems gives new meaning to the word “reliability”.”We show up when we say we will, we do the job with the expertise of over 52 years in the business, and we tidy up. We never leave a mess!””When you require garage door service or garage door electric opener attention, please call us. You won’t be sorry. We guarantee it!”Having done that, just sit down and relax, you have just hired Greater Toronto’s #1 garage door company, Dodds Garage Door Systems is your RELIABLE garage door firm.Dodds major products are “SERVICE”, “VALUE”, and “CUSTOMER SATISFACTION!”
Dodds Garage Door Systems Inc. is an all-Canadian privately owned company, established in 1958, specializing in the sale, repairs, service and installation of:
Overhead Garage Doors- residential, commercial and industrial Electric Garage Door Openers – residential, commercial and industrial
Fix Dents Or Damage In The Track
If there is any damage to the track, it will need to be fixed for the door to move smoothly. First, use a hammer and chisel to remove any dents or debris in the way. Then, use a wire brush to clean off the track and make sure it is smooth. If there is any damage to the metal, you will need to repair it before proceeding. Once the track is clean and undamaged, proceed to the next step.
Don’t Miss: 100 Miles Of Garage Sales
Broken Or Damaged Spring
If your spring snapped and you were home, you likely heard it. Its a sharp, cracking sound and it means that the garage door wont be going anywhere anytime soon.
While labor can cost almost as much as a new garage door itself, you can replace a spring with the right tools and know-how.
Before you go, make sure to take measurements of your broken spring. Pictures are helpful too. Then, compare them with our stock and check out the video tutorial on how to replace a spring.
Commercial Garage Door Experts
No matter what type of industry you work with, you can understand the importance of maintaining efficiency, security and lasting value. And with a sturdy commercial garage door, business owners can address these operating needs and improve their overall daily performance. At Markham Garage Doors, we have a large stock of Clopay commercial garage door products and accessories, including steel overhead doors, roll-up sheet doors and security doors.
You May Like: Prices On Garage Door Openers
Manually Check The Alignment
Once all rollers are back in place, lift the garage door manually. This may require two people depending on the weight of your door. Dont hurt yourself!
If the rollers work properly and the door goes all the way up, congrats!
But dont stop there. Manually close and reopen the door a few times to ensure the door is repeatedly functioning correctly. If there are issues, they should become evident after a few tries.
What Causes A Garage Door To Go Offtrack
There are several reasons why your garage door may have gone off track. The most common reason is that the door was not installed properly in the first place. If the door is not installed level, it can cause the door to go off track. Other causes include:
- Worn-out rollers: Over time, the rollers on your garage door can become worn out. This can cause them to slip off the tracks and cause the door to go off track.
- Damaged tracks: If your tracks are bent or damaged, it can cause the door to go off track.
- Loose hardware: If any of the bolts or nuts holding your garage door together are loose, it can cause the door to come off the tracks.
If your garage door has gone off track, there are a few things you can do to try and fix it yourself. However, if the damage is severe, it is best to call a professional for help.
Also Check: My Garage Door Won’t Close